基于掺加聚酯纤维的沥青混合料对比试验研究
Experiment Study on the Polyester Fiber Mix into Asphalt Mixture

作者: 谢民伟 :杭州市交通工程集团有限公司,杭州; 冯宝平 :陕西省高速公路建设集团公司,西安;

关键词: 聚酯纤维路用性能沥青混合料改性沥青Polyester Fiber Road Service Performance Asphalt Mixture Modified Asphalt

摘要:
文章对相同配合比的基质沥青、掺加4.5%SBS改性剂和同时掺加0.25%聚酯纤维与4.5%SBS改性剂的混合料分别进行了马歇尔稳定度试验、车辙试验、劈裂试验、残留稳定度和冻融劈裂试验,研究三种沥青混合料的马歇尔稳定度、水稳定性、高温稳定性及低温抗裂性。结果表明:掺加SBS改性剂和聚酯纤维后,沥青混合料的高温稳定性能得到改善。抗车辙能力和低温性能优劣依次为掺加聚酯纤维和SBS改性沥青混合料、SBS改性沥青混合料、基质沥青混合料。残留稳定度和冻融劈裂强度比的优劣顺序为:纤维沥青混合料、SBS改性沥青混合料、基质沥青混合料。

Abstract:
The paper analyzes three kinds of asphalt mixture with the same gradation mixture of matrix asphalt, adding 4.5% SBS modified mixes agent and simultaneously adding 0.25% polyester fiber and 4.5% SBS modifier. The three kinds of mixture are conducted by Marshall stability test, rutting test, split test, residual stability and freeze-thaw splitting test, aiming to properties of mixture Marshall stability, water stability, high temperature stability and low temperature crack resistance. The results show that the high temperature stability, asphalt mixture rutting resistance and low temperature properties of asphalt mixture can be improved by the addition of the SBS modifier and polyester fiber. Asphalt mixture with polyester fiber and SBS modifier is better than that of SBS modified asphalt and asphalt mixture in the aspects of rutting resistance, low temperature performance, water stability and freeze-thaw splitting strength ratio.

文章引用: 谢民伟 , 冯宝平 (2013) 基于掺加聚酯纤维的沥青混合料对比试验研究。 交通技术, 2, 138-141. doi: 10.12677/OJTT.2013.22025

参考文献

[1] 李洪斌. 纤维稳定剂对沥青混合料路用性能影响分析[J]. 中外公路, 2005, 25(6): 113-115.

[2] 沈金安. 沥青及沥青混合料路用性能[M]. 北京: 人民交通出版社, 2003.

[3] 孙同策. 纤维沥青混凝土试验及应用[J]. 公路交通科技, 2005, 22(2): 20-23.

[4] 李明, 邹勃. 聚酯纤维增强沥青混合料性能研究[J]. 西部交通科技, 2007, 1: 44-46.

分享
Top