单轴电液角振动台的迭代复现控制研究
Study on Iteration Reproduction Control of Single-axis Electro-hydraulic Angular Vibration Table

作者: 袁立鹏 :哈尔滨工业大学机电工程学院;康奈尔大学机械与航空航天工程学院,伊萨卡,美国; 袁立铭 :首都航天机械公司,北京,中国; 李海金 :黑龙江农业工程职业学院,哈尔滨,中国;

关键词: 三状态控制 频响函数估计 随机复现振动算法 three variables controller frequency response estimator random vibration iteration control algorithm

摘要:

液压角振动台是十分复杂的非线性系统,应用传统的控制系统设计方法很难满足其控制要求。针对随机振动要求振动试验系统具有高频响性能的特点,建立了阀控马达系统的数学模型,根据极点配置原理设计了有效拓展系统频宽的三状态控制器。提出基于自适应滤波器频响函数辨识方法进行复合迭代控制,并研究了不同阀控马达频响函数估计方法对随机复现振动控制精度的影响效果。将仿真结果与实验数据进行对比分析,验证了三状态控制策略拓展系统频宽的有效性和自适应滤波器频响函数估计的准确性。

Hydraulic angular vibration table is a kind of complex and non-linear system. Applying traditional controller to the angular vibration system, it is difficult to make the control performance to a high level. Aiming at the demand of high frequency response for the random vibration system, this paper built up the mathematical model of hydraulic motor controlled by valves, and according to the principle of pole assignment, this paper designed the three variables controller for the electro-hydraulic servo angular vibration table, which can extend the system bandwidth. This paper proposes the random vibration composite iteration control algorithm based on the frequency response estimator using self-adapting filter. The control precision of the different frequency response estimators was analyzed. Comparing simulation with experiment, the results show that three variables controller is favorable to improve system’s frequency response and the frequency response estimator using self-adapting filter is accurate for random vibration replication control.



Abstract:

文章引用: 袁立鹏 , 袁立铭 , 李海金 (2012) 单轴电液角振动台的迭代复现控制研究。 力学研究, 1, 13-19. doi: 10.12677/IJM.2012.12003

参考文献

[1] B. Peeters, J. Debille. MIMO random vibration control algorithm and simulations. Proceedings of the 72nd Shock and Vibration Symposium, San Destin, 2001: 116-122.

[2] M. Tanka, Y. Kaneda. A fast projection algorithm for adaptive fil- tering. IEICE Transactions on Fundamentals of Electronics, Com- munications and Computer Science, 1995, E78-A(10): 60-68.

[3] R. Pintelon, J. Schoukens. Measurement of frequency response functions in the presence of correlated input/output errors. IEEE Instrumentation and Measurement Technology Conference, Budapest, 2001: 618-626.

[4] 关广丰, 从大成, 韩俊伟, 李洪人. 6自由度随机振动控制算法[J]. 机械工程学报, 2008, 9: 56-60.

[5] 倪镜根, 李锋. 一种新的变步长最小均方自适应滤波算法[J]. 信息和电子工程, 2008, 20(3): 10-16.

分享
Top