高炉灰和澳精粉配比对直接还原行为的影响
Effect of Blending of Blast Furnace Ash and Australian Fine Powder on Direct Reduction Behavior

作者: 李世钦 , 袁 骧 , 李 洋 :北京科技大学,北京 ;

关键词: 高炉灰澳精粉直接还原Blast Furnace Ash Australian Fine Powder Direct Reduction

摘要:
高炉灰是炼铁工艺的主要副产品,通过转底炉法处理高炉灰可以有效的回收这种废弃物。本文用两种高炉灰与澳精粉混合制备成含碳球团,全文通过煤粉与澳精粉制备的含碳球团进行对比,研究不同碳氧比对还原行为的影响,结果表明:随着碳氧比的升高,三种含碳球团金属化率均增大,但是金属化率的大小始终未煤粉球团 > 布袋灰球团 > 重力灰球团。三种球团的抗压强度和体积收缩都随着碳氧比的增加而降低。运用高炉灰与澳精粉制备金属化球团是可行的,具有很高的环保意义和应用前景。

Abstract: Blast furnace ash is the main by-product of iron making process. It can effectively recover this kind of waste by treating blast furnace ash by turning furnace. In this paper, two kinds of blast furnace ash and Australian powder were prepared and mixed with carbon pellets. The effects of different carbon and oxygen ratios on the reduction behavior were studied by comparing the carbon pellets prepared by pulverized coal and Australian powder. The results showed that with the increase of carbon and oxygen ratio, the metallization rate of the three kinds of carbon pellets increased, but the size of the metallization rate was not always pulverized coal pellets > bag gray pellets > gravity gray pellets. The compressive strength and volume shrinkage of the three pellets are reduced with the increase of the carbon-oxygen ratio. The use of blast furnace ash and Australian powder to prepare metallized pellets is feasible and has a high environmental significance and application prospects.

文章引用: 李世钦 , 袁 骧 , 李 洋 (2017) 高炉灰和澳精粉配比对直接还原行为的影响。 冶金工程, 4, 158-164. doi: 10.12677/MEng.2017.43023

参考文献

[1] 张汉良. 高炉瓦斯泥综合利用评述[J]. 金属矿山, 2008, 11(增刊): 131-136.

[2] 王涛. 国外钢厂含锋粉尘的循环利用[J]. 炼钢, 2002, 18(5): 50-54.

[3] 杨丽芬. 国外含铁尘泥的处理与利用技术简介[J]. 冶金环保情报, 1992(3): 12.

[4] 郭延杰. 日本钢铁厂含锌粉尘的综合利用[J]. 中国资源综合利用, 2003(1): 4-5.

[5] 佘雪峰, 薛庆国, 董杰吉, 等. 钢铁厂典型粉尘的基本物性与利用途径分析[J]. 过程工程学报, 2009, 9(1): 7-12.

[6] 巨建涛, 党要均. 钢铁厂含锌粉尘处理工艺的现状及发展[J]. 材料导报, 2015, 28(5): 109-113.

[7] 胡晓军, 郭婷, 周国志. 含锌冶金粉尘处理技术的发展和现状[J]. 钢铁研究学报, 2011, 23(7): 1-5.

[8] 许海川, 周和敏, 齐渊洪, 等. 转底炉处理钢厂固废工艺的工程化及其生产实践[J]. 钢铁, 2012, 47(3): 89-93.

[9] 王东彦, 陈伟庆, 周荣章, 等. 处理含锌铅钢铁厂粉尘的Inmetco工艺[J]. 环境工程, 1997, 15(3): 49-52.

[10] 孟巍, 王传琳. 高炉含锌粉尘综合利用的研究[C]//第八届(2011)中国钢铁论文集: 2011年卷. 北京, 2011: 2078-2084.

[11] 张建良, 闫永芳, 徐萌, 等. 高炉含锌粉尘的脱锌处理[J]. 钢铁, 2006, 41(10): 78-81.

[12] 巨建涛, 党要均, 赵忠宇, 等. 高炉除尘灰和转炉尘泥的还原脱锌试验[J]. 钢铁钒钛, 2013, 34(4): 36-40.

[13] 邢相栋, 张建良, 曹明明, 等. 高炉含锌粉尘中铁资源的富集回收[J]. 矿业工程, 2012, 32(3): 86-88.

[14] 刘瑜, 刘秉国, 邢晓钟. 高炉瓦斯泥碳热还原脱锌研究[J]. 无机盐工业, 2013, 45(10): 39-41.

分享
Top