响应面法优化超声辅助竹茹总黄酮提取工艺研究
Optimizing of Ultrasonic-Assisted Extraction Technology of Total Flavonoids from Bambusae caulis in Taenias Based on Response Surface Methodology

作者: 管红梅 * , 吴 冲 , 姜登钊 :九江学院药学与生命科学学院,江西 九江;

关键词: 竹茹总黄酮超声辅助响应面法Bambusae caulis in Taenias Total Flavonoids Ultrasonic-Assisted Response Surface Methodology

摘要:
目的:研究超声辅助提取竹茹总黄酮的最佳工艺条件。方法:在单因素试验基础上,选取乙醇浓度、料液比、超声功率及超声时间为影响因素,采用中心组合实验设计,以竹茹总黄酮提取率为响应值进行响应面分析。结果最佳工艺条件为:乙醇浓度67%、料液比1:25、超声功率330 W、超声时间26 min,竹茹总黄酮得率为3.557%。结论:该工艺提取率高、操作简便,可为竹茹总黄酮的提取提供参考。

Abstract: Objective: To optimize of ultrasonic-assisted extraction technology of total flavonoids from Bambusae caulis in taenias based on response surface methodology. Method: On the basis of single-factor experiment, four parameters including ethanol concentration, solid-liquid ratio, ultrasonic power and ultrasonic time were selected as influencing factors and the optimum conditions for total flavonoids extract were obtained through Box-Behnken center united experiment designed by response surface methodology. Results: The optimum conditions were as follows; the ethanol concentration was 67%; the solid-liquid ratio was 1:25; the ultrasonic power was 330 W and the ultrasonic time was 26 min. Under the conditions, the extraction rate of total flavonoids could be reached to 3.557%. Conclusion: This method is simple, rapid and reliable which could provide reference for the producing of total flavonoids from Bambusae caulis in taenias.

文章引用: 管红梅 , 吴 冲 , 姜登钊 (2017) 响应面法优化超声辅助竹茹总黄酮提取工艺研究。 药物资讯, 6, 63-71. doi: 10.12677/PI.2017.63011

参考文献

[1] 国家药典委员会. 中华人民共和国药典(一部) [S]. 北京: 中国医药科技出版社, 2015: 139.

[2] 姚晓宝. 竹茹中三萜类化合物的研究[D]: [硕士学位论文]. 杭州: 浙江大学, 2004.

[3] 楼鼎鼎. 竹茹超临界萃取物的组成分析和功能性研究[D]: [硕士学位论文]. 杭州: 浙江大学, 2005.

[4] Jiao, J., Zhang, Y., Lou, D., et al. (2007) Antihyperlipidemic and Antihypertexisive Effect of a Triterpenoid-Rich Extract from Bamboo Shavings and Vasodilator Effect of Friedelin on Phenylephrine-Induced Vasoconstriction in Thoracic Aortas of Rats. Phytotherapy Research, 21, 1135-1141.
https://doi.org/10.1002/ptr.2223

[5] Zhang, Y., Yao, X., Bao, B., et al. (2006) Anti-Fatigue Activity of a Triterpenoid-Rich Extract from Chinese Bamboo Shavings (Caulis bamfusae in taeniam). Phytotherapy Research, 20, 872-876.
https://doi.org/10.1002/ptr.1965

[6] Lu, B., Liu, L., Zhen, X., et al. (2013) Anti-Tumor Activity of Triterpenoid-Rich Extract from Bamboo Shavings (Caulis bamfusae in Taeniam). African Journal of Biotechnology, 9, 6430-6436.

[7] 黄菊青. 竹茹多糖的化学结构和免疫活性研究[D]: [博士学位论文]. 杭州: 浙江大学, 2015.

[8] 陈红梅, 谢翎. 响应面法优化半枝莲黄酮提取工艺及体外抗氧化性分析[J]. 食品科学, 2016, 37(2): 45-50.

[9] 杨仙凌. 响应面法优化拳参总蒽醌超声提取工艺的研究[J]. 中华中医药学刊, 2013, 31(2): 408-410.

[10] Yan, Y., Yu, C., Chen, J., et al. (2011) Ultrasonic-Assisted Extraction Optimized by Response Surface Methodology, Chemical Composition and Antioxidant Activity of Polysaccharides from Tremella mesenterica. Carbohydrate Polymer, 83, 217-224.
https://doi.org/10.1016/j.carbpol.2010.07.045

[11] 严云良, 余陈欢. 响应面分析法优化小鱼仙草总黄酮的提取工艺研究[J]. 数理医药学杂志, 2010, 23(2): 194-197.

分享
Top