Design of Speed Control System for PMSM Based on Three-Level Structure
Abstract: The three-phase PMSM has a very broad prospect in saving electrical energy. It has the characte-ristics of simple structure, small volume, high efficiency and good heat radiation. Compared with conventional two-level inverters, three-level inverter has a series of advantages such as low vol-tage-proof for single transistor, low switching loss and low harmonic content, etc. Therefore, it is of great theoretical significance and practical value to apply the three-level inverter to the speed regulating system of permanent magnet synchronous motor (PMSM). In this paper, the speed regulating system of permanent magnet synchronous motor on the basis of three level neutral point clamped (NPC) inverter is studied. Rotor flux oriented vector control method is applied on the motor. In order to implement the control process, zero sequence voltage injection method is introduced in the proposed three-level inverter control system. With this method, the balance of the neutral point voltage can be well achieved to reduce the harmonic content of the output voltage of the inverter and improve the stator current waveform, which will further minimize the motor torque ripple, and improve motor control performance. The mathematical model and vector control method of PMSM are introduced in this paper, both the topology and commutation mode of three-level inverter with neutral point clamping mode are described, and the neutral point potential balance algorithm and modulation strategy are also analyzed. Finally, the experiment verified the reliability and stability of the system.
文章引用: 吴 丰 , 许倩倩 (2017) 基于三电平的永磁同步电机调速系统的设计。 电气工程， 5， 25-33. doi: 10.12677/JEE.2017.51004
 金永顺. 三电平逆变器SVPWM方法的分析与研究[D]: [硕士学位论文]. 长沙: 湖南大学, 2007.
 肖卫文. 永磁同步电机电磁系统的研究[D]: [硕士学位论文]. 长沙: 湖南大学, 2009.
 Rodriguez, J., Lai, J.S. and Peng, F.Z. (2002) Multilevel Inverters: A Survey of Topologies, Controls, and Applications. IEEE Transactions on Industrial Electronics, 49, 724-738.
 邵章平. 三电平背靠背变流器系统的关键技术研究[D]: [硕士学位论文]. 合肥: 合肥工业大学, 2011.
 张志, 谢云强, 等. 一种消除中点电位低频振荡的三电平逆变器载波调制方法[J]. 电力自动化设备, 2010, 30(4): 1-3.
Nabae, A., Takahashi, I. and Akagi, H. (1981) A New Neutral Point Clamping PWM Inverter. IEEE Transactions on Industry Applications, 17, 518-523.
 Yuan, X.M. and Barbi. I. (2000) Fundamentals of a New Diode Clamping Multilevel Inverter. IEEE Transactions on Industrial Electronics, 15, 711-718.