复合生物反应器对甲醛废气净化性能最大化研究
The Research on Performance Maximization of Purifying Formaldehyde Emission by Composite Bioreactor

作者: 雷艳梅 :山东省冶金设计院股份有限公司,山东 济南; 王 洁 , 孙珮石 :云南大学工程技术研究院,云南 昆明;

关键词: 复合生物反应器甲醛废气净化性能Composite Bioreactor Formaldehyde Emissions Purification Performance

摘要:
本文采用复合生物反应器对甲醛废气的净化性能进行了实验研究,考察了进口气体浓度和气体流量的改变对甲醛净化性能的影响。结果表明:当pH值控制在6~8、气体流量为400 L/h、循环液流量为10 L/h、甲醛进口气体浓度为300 mg/m3时,复合生物反应器对甲醛废气有最大净化性能,其最大生化去除量可达到13.70 mg/(L∙h)。

Abstract: In this paper, the performance of purifying formaldehyde emission by composite bioreactor was investigated experimentally. The effects of changes in import gas concentration and gas flow rate on formaldehyde purification performance were examined. The experimental results indicated that when the pH was controlled at 6 - 8, the gas flow rate was 400 L/h, the circulating fluid flow rate was 10 L/h, and the concentration of formaldehyde imported gas was about 300 mg/m3, compound bioreactor was biggest for purification performance of formaldehyde emission. The maximum amount of biochemical removal can reach 13.70 mg/(L∙h).

文章引用: 雷艳梅 , 王 洁 , 孙珮石 (2015) 复合生物反应器对甲醛废气净化性能最大化研究。 化学工程与技术, 5, 88-93. doi: 10.12677/HJCET.2015.54014

参考文献

[1] 李晶平, 鲁统布, 陆慧玲 (2006) 甲醛毒性及其常用检测方法. 中山大学研究生学刊, 26, 34-38.

[2] 梁建聪, 郭云霞, 容学军 (2009) 甲醛污染来源及防治措施. 广西轻工业, 124, 100-101.

[3] 牛凤兰, 宋德锋, 陈林 (2009) 环境中甲醛污染来源及检测方法新进展. 上海预防医学杂志, 21, 453-455.

[4] Cole, P. and Axten, C. (2004) Formaldehyde and leukemia: An improbable causal relationship. Regulatory Toxicology and Pharmacology, 40, 107-112.
http://dx.doi.org/10.1016/j.yrtph.2004.06.001

[5] Conolly, R.B., Kimbell, J.S., Janszen, D., et al. (2004) Human respiratory tract cancer risks of inhaled formaldehyde: Dose response predictions derived from biologically motivated computational modeling of a combined rodent and human dataset. Toxicological Sciences, 82, 279-296.
http://dx.doi.org/10.1093/toxsci/kfh223

[6] Mautz, W.J. (2003) Exercising animal models in inhalation toxicology: Interactions with ozone and formaldehyde. Environmental Research, 92, 14-26.
http://dx.doi.org/10.1016/S0013-9351(02)00024-5

[7] Tyihak, E., Bocsi, J., Timar, F., et al. (2001) Formaldehyde promotes and inhibits the proliferation of cultured tumour and endothelial cells. Cell Proliferation, 34, 135-141.
http://dx.doi.org/10.1046/j.1365-2184.2001.00206.x

[8] Kovacic, P. (2005) Role of oxidative metabolites of cocaine in toxicity and addiction: oxidative stress and electron transfer. Medical Hypotheses, 64, 350-356.
http://dx.doi.org/10.1016/j.mehy.2004.06.028

[9] Shangari, N. and O’Brien, P.J. (2004) The cytotoxic mechanism of glyoxal involves oxidative stress. Biochemical Pharmacology, 68, 1433-1442.
http://dx.doi.org/10.1016/j.bcp.2004.06.013

[10] Kim, W.J., Terade, N., Nomura, T., et al. (2002) Effect of for-maldehyde on the expression of adhesion molecules in nasal microvascular endothelial cells: the role of formaldehyde in the pathogenesis of sick building syndrome. Clinical & Experimental Allergy, 32, 287-295.
http://dx.doi.org/10.1046/j.1365-2222.2002.01301.x

[11] Patel, K.G., Bhatt, H.V. and Choudhury, A.R. (2003) Alteration in thyroid after formaldehyde (HCHO) treatment in rats. Industrial Health, 41, 295-297.
http://dx.doi.org/10.2486/indhealth.41.295

[12] Liu, Y.S., Li, C.M., Lu, Z.S., Ding, S., Yang, X. and Mo, J. (2006) Studies on formation and repair of formaldehyde damaged DNA by detection of DNA-protein crosslinks and DNA breaks. Frontiers in Bioscience, 11, 991-997.
http://dx.doi.org/10.2741/1856

[13] 梁建聪, 郭云霞, 容学军 (2009) 甲醛污染来源及防治措施. 广西轻工业, 3, 100-101.

[14] Fujishima, A., Rao, T.N. and Tryk, D.A. (2000) Titanium dioxide photocatalysis. Journal of Photo-chemistry and Photobiology C, 1, 1-21.
http://dx.doi.org/10.1016/S1389-5567(00)00002-2

[15] Tryk, D.A., Fuji-shim, A. and Honda, K. (2000) Recent topics in photoelectrochemistry: Achievements and future prospects. Electro-chimica Acta, 45, 2363-2376.

[16] 汪士林 (2007) 对甲醛污染的控制与治理的几点看法. 江西化工, 4, 232-233.

[17] 周中平, 赵寿堂, 朱立, 等 (2002) 室内污染检测与控制. 化学工业出版社, 北京, 321-322.

[18] 白雁斌, 刘兴荣 (2003) 吊兰净化室内甲醛污染的研究. 海峡预防医学杂志, 3, 26-27.

[19] Mirdamadi, S., Rajabi, A., Khalilzadeh, P., Norozian, D., Akbarzadeh, A. and Mohseni, F.A. (2005) Isolation of bacteria able to metabolize high concentrations of formaldehyde. Microbiology & Biotechnology, 21, 1299-1301.

[20] Mitsui, R., Omori, M., Kitazawa, H. and Tanaka, M. (2005) Formaldehyde-limited cultivation of a newly isolated methylotrophic bacterium, Methylobacterium sp. MF1: Enzymatic analysis related to C1 metabolism. Journal of Bioscience and Bioengineering, 99, 18-22.

[21] Eiroa, M., Kennes, C. and Veiga, M.C. (2004) Formaldehyde biodegradation and its inhibitory effect on nitrification. Journal of Chemical Technology & Biotechnology, 79, 499-504.
http://dx.doi.org/10.1002/jctb.1011

[22] 乔莉, 李晓梅, 孙珮石, 王洁, 杨常亮 (2009) 高浓度甲醛废气的生物法处理实验研究. 云南大学学报(自然科学版), 1, 80-83.

[23] 王洁, 孙珮石, 邹平 (2010) 液相曝气池对甲醛废气净化的促进作用研究. 2010年环境污染与大众健康学术会议论文集(CEPPH2010), 武汉, 88-92.

[24] 谢文娟, 王洁, 孙珮石, 邹平 (2011) 高效降解甲醛菌株的分离鉴定及其特性. 微生物学通报, 11, 1626-1631.

[25] 国家环境保护总局 (2003) 空气和废气监测分析方法. 第四版增补版, 中国环境科学出版社, 北京.

[26] 国家环境保护总局 (2003) 水和废水监测分析方法. 第四版增补版, 中国环境科学出版社, 北京.

分享
Top