燃油电加热器内部温度场数值模拟
Numerical Study on the Temperature Field of an Oil Electric Heater

作者: 牛明田 :海军驻大连船舶重工集团有限公司军事代表室,大连; 蔡 林 , 刘东民 , 宋振国 :中国舰船研究设计中心,武汉;

关键词: 燃油电加热器自然对流非稳态换热CFD Oil Electric Heater Nature Convection Transient Heat Transfer CFD

摘要:

本文利用计算流体力学(CFD)方法对某型燃油加热器进行了数值计算。考虑浮升力作用的自然对流换热及燃油流动带来的强制对流换热,研究了不同布置方案对燃油加热器内部温度场分布的影响,结果表明:当进口在上方时,出口温度要高于其他工况。最后进行了电加热器非稳态流场的计算,分析了电加热器静态预热温度场,给出了电加热器预热的时间范围,并结合非稳态温度场结果分析了监测点布置方案。

This paper investigates the Fuel-oil Electric Heater (FEH) flow field using CFD method. Both natural convection caused by buoyancy lift and forced convection caused by oil flow have been considered; the effects of equipment arrangement on temperature field distribution have been analysed. The results show that when inlet is located above, the outlet temperature is higher than other cases. At last, the unsteady flow field has also been calculated for preheating process, and the preheating time range and temperature sensors’ location have been pointed out.



Abstract:

 

文章引用: 牛明田 , 蔡 林 , 刘东民 , 宋振国 (2013) 燃油电加热器内部温度场数值模拟。 应用物理, 3, 115-119. doi: 10.12677/APP.2013.36022

参考文献

[1] 穆勇, 郑洪涛. 增压锅炉烟气发生器燃烧流场与污染排放数值分析[J]. 机械设计与制造. 2010, 3: 190-192.

[2] 甘晓华. 航空燃气轮机燃油喷嘴技术[M]. 北京: 国防工业出版社, 2006.

[3] 史美中, 王中铮. 热交换器原理与设计[M]. 南京: 东南大学出版社, 2008.

[4] 平洋, 罗雄麟. 电加热器温度仿人智能多模型控制[J]. 化工自动化及仪表, 2010, 37(8): 30-33.

[5] D. Sahray, H. Shmueli, G. Ziskind and R. Letan. Study and op- timization of horizontal-base pin-fin heat sinks in natural con- vection and radiation. Journal of Heat Transfer, 2012, 132(1): 1-11.

[6] A. Trombe, A. Suleiman and Y. Le Maoult. Use of an inverse method to determine natural convection heat transfer coeffi- cients in unsteady state. Journal of Heat Transfer, 2003, 125(6): 1017-1025.

[7] 杨世铭, 陶文铨. 传热学[M]. 北京: 高等教育出版社, 1998.

分享
Top